Home       Contact
  Login         Register        View Your Basket
Search
The UK's best replacement part site - we strive to offer the best internet value on our mobility products

Mobility Scooter Batteries

Deciding which battery you want may seem complicated at first, but a few simple steps will enable you to select the correct one for your machine.


GEL batteries produce more cycles than SLA batteries and therefore they have the ability to last longer than SLA batteries. Below is a summary of the two types.


Sealed Lead Acid Batteries

Sealed Lead Acid
Mobility Scooter Batteries



  • Lower cost than Gel batteries
  • Maintenance FREE
  • Sealed & Non-Spillable
  • Air Transportable
  • Recommended for light and occasional scooter users


Recommended for occasional mobility scooter users, Sealed Lead Acid batteries (SLA) offer fantastic value for money with good performance. These batteries are also suitable for electric bikes such as Powabykes.
  GEL Batteries

GEL
Mobility Scooter Batteries



  • Superior cycle life
  • Maintenance FREE
  • Sealed & Non-Spillable
  • Air Transportable
  • Recommended for power chair and everyday scooter users


Recommended for daily mobility scooter and powerchair users, GEL mobility batteries are the ultimate battery, offering unrivalled performance. These batteries are also suitable for electric golf buggies and trolleys.

Mobility Battery Finder

All scooter / electric wheelchair batteries are 12 volt and are usually fitted in pairs giving a 24 volt output. It is recommended that when replacing batteries they are fitted in pairs.


The power output is marked in amp hours (Ah) on the side of the battery E.g. 12 volt 35A/h. The amp hour rate may vary slightly from different manufacturers for a similar size battery, therefore the critical thing is the physical size of the battery.


The next thing you need to decide once you have identified which battery Amp hour you require, is whether you want a GEL battery or an AGM (Absorbed Glass Mat) battery this is often referred to as a sealed lead acid (SLA) battery.


Both batteries are sealed, non-spillable and maintenance free. The main difference between them is the performance/longevity. As the battery in a scooter or power chair is the only power source the battery is designed to work differently to other batteries, like car batteries for example.


A car battery is designed for starting the car, therefore it is required to produce a large amount of power immediately as you turn the key, and is then constantly trickle charged. A GEL or SLA battery is designed to give a constant flow of power over a longer period, and then to be recharged fully, this is called a cycle.


Battery Installation

  • Take a look at our YouTube video "How to change mobility scooter batteries" using the link below.
  • Wheelchairs and scooters typically require two batteries with 24-volt series connection. Never mix and match different battery manufacturers or technologies, or use batteries that do not have similar date codes. Never mix Gel batteries and AGM batteries.
  • Always fully charge batteries prior to use
  • Follow installation and start-up instructions provided by the mobility equipment manufacturer.

Break-In Period

Active users of power wheelchairs cycle their batteries daily (deep cycling). This stringent application requires a unique battery design that will sometimes compromise initial capacity in return for longer battery life.

Gel battery performance improves once the battery has been cycled (discharged and recharged) 20-25 times. This break-in period is necessary to fully activate the battery for maximum performance and longevity. Thus, range and running time of your mobility device could initially increase with use.


When to charge?

  • Charge Daily
  • The charger supplied with your mobility device should fully charge your batteries overnight. Overcharging is not a problem with today’s smart chargers as they are voltage limited and shut off automatically. Sealed Gel and AGM batteries do not exhibit a "use it or lose it" capacity-robbing effect known as "memory".
  • Mobility Pitstop stock a range of mobility scooter and powerchair battery chargers for all battery tyres.

Proper Charging Guidelines

  • Use the equipment manufacturer’s automatic charger for all routine charging or a suitable equivalent.
  • Never use an automotive or wet-type charge on Sealed Gel or AGM batteries as doing so will damage your battery.
  • Depth of discharge affects cycle life. The harder a battery has to work the shorter its life expectancy.
  • Avoid ultra-deep discharges and never drain your batteries completely.
  • Do not leave your batteries in a low state of charge for an extended length of time. Charge a discharged battery as soon as possible.
  • Do not cycle your batteries at a low state of charge without regularly recharging them fully.


Storage and Maintenance

  • Always store your batteries FULLY CHARGED
  • Check all stored batteries once a month and recharge as needed.
  • Fully charged Sealed Gel and AGM batteries can hold a charge for up to 6 months, however, they should always be charged before use.
  • When storing a power chair or scooter for more than 4 weeks, charge the batteries first and then disconnect them for storage.
  • Avoid hot and cold extremes when storing.
  • Sealed Gel and AGM batteries require no watering. Any performance-related issues should be handled by a properly trained wheelchair or scooter technician.

Safety

Batteries can be hazardous
  • Dropping a tool or touching a watch or bracelet across the terminals can result in an electrical shock, sparks, smoke, fire and even and explosion. Use extreme caution around exposed battery terminals.
  • Battery posts, terminals and related accessories contain lead and lead compounds, and other chemicals known to the state of California to cause cancer and birth defects or other reproductive harm. Wash hands after handling.
  • BE CAREFUL! Batteries produce explosive gases. Keep sparks, flames and cigarettes away from batteries at all times. ALWAYS wear safety glasses and a face shield when working on or near batteries. Ventilate well. Do not install in an airtight container.
  • All old batteries are consider “hazardous material” and must be recycled through an approved agency to prevent improper disposal. Lead-acid batteries are virtually 100% recyclable.


The chart below shows approximate sizes in both millimetres and inches for each battery size. Within the product description on mobilitypitstop.com you will find the dimensions of each battery.


Millimetres Inches
Battery Ah Length Width Height Length Width Height
1.3Ah 97 43 59 3.82 1.69 2.28
2.2Ah 178 34 66 7 1.38 2.5
2.9Ah 79 56 106 3.06 2.19 4
3.4Ah 134 67 66 5.25 2.63 2.44
5Ah 90 70 108 3.54 2.76 4.21
8Ah 151 65 100 5.94 2.56 3.94
10Ah 151 65 114 5.94 2.56 4.61
12Ah 151 99 100 5.94 3.88 3.88
15Ah 151 99 100 5.94 3.88 3.88
18Ah 181 76 167 7.13 3 6.5
22Ah 181 76 167 7.13 3 6.5
27Ah 166 175 125 6.5 6.87 4.94
35Ah 195 131 181 7.68 5.16 7.13
40Ah 196 165 165 8 6.5 6.5
50Ah 196 165 165 8 6.5 6.5
55Ah 229 138 232 9 5.43 9.13
60Ah 259 169 178 10.25 6.625 7
75Ah 260 168 232 10.25 6.61 9.13






Cards Accepted
© 2008-2014 mobilitypitstop.com All rights reserved.